Like many RV of ANY age (ours is 46 years old this year-2019!) there never seems to be enough kitchen counter space. Especially now with the advent of Instapots, Keurig coffee machines, etc. there are times where we just need MORE!
Here is a 1/2 day project we did to nearly double the size of our counter space in our 1973 Avion, 28 foot LaGrande model.
1 wood topped snack/TV table tray. Here is the $10 one we used purchased at our Walmart. (we already had a set of these in our sticks n bricks home, so no cost to our project!)
Aprox. 3/4″ thick x 2″wide wood strip (for support inside drawer cabinet). Length should be based on interior cabinet (under countertop) to floor of cabinet.
Screws (will vary based on thickness of your exterior wall base cabinet)
sheet of paper (for making a template)
flashlight (to have helper light up inside base cabinet for marking drill holes)
extra pair of hands-always helps and is needed!
NOTE: If you prefer to purchase a kit from Camco for a 12″ counter extension here is that product along with an install video which may help you even if you do the do-it-yourself one like we did below. Camco RV Counter Extension Kit
We took the folding legs and wood hardware bracket off of the snack table.
We made a paper template of the positions for the hinges by placing on tray back, taking measurements of the distance in between the 2 brackets we felt would provide optimal support.
This template will later help us know where on the side of the kitchen base cabinet we need to drill our pilot holes. You can choose to position your lift up counter extension at same height as your existing kitchen counter or just below. We recommend to install it just below the bottom edge of our formica countertop. By doing it that way, our extension, when folded down is flush with the cabinet. See position below.
Using the hinge template, we made marks on the exterior side of our kitchen base cabinet where we wanted the hinges placed. Careful to take into account that your hinges are going to be below the finished edge of your extension snack table board.
We measured from just under the formica counter edge down to the position of the top holes for the hinges to ensure this jived with our template.
We used the template to figure out where on the INSIDE of our base cabinet (drawers had been pulled out) that our vertical wood slat needed to be positions to provide additional support to the cabinet once hinges and extension table was in place.
Here is a photo of the wood support slats in place waiting to receive the screwed in hinges from the outside. Note, we used small screws that did not protrude through the base cabinet but were sufficient to hold the slats in place independently before we proceeded with project from outside of the base cabinet.
We then double checked and with a pencil marked the holes using our template were we would be screwing in the hinges onto the exterior side of the base cabinet, and screwed in the hinges. Be sure to ensure they are level. Install 1, then use this to hold your level in place while you position the second one the same distance apart as your wood slats are on the inside that are being used as support to receive the long screws that go from the hinge exterior, through your base cabinet wall and sink into the wood support slate on inside of cabinet.
Next we used the template again to drill pilot holes into the underside of table tray top. Ours was oak and very hard so pilot holes are a must. It should be noted that wood top snack trays come in many colors, honey oak, walnut, etc. and you may wish to select a tray top that compliments your base cabinets. We used a snack tray we already had on hand to save money-hence the “butcher block” look rather than matching our base cabinet stain.
Perhaps the hardest part of the whole project was laying the tray table down on fully deployed and locked in place hinges and from the bottom, screwing the table top to the hinges. This really does require a helper to ensure the top stays in place and is level.
We spent the following week preparing for our big trip out to Elkhart, Indiana to enjoy the Silver Avion Fellowship Rally with 41, count ’em…41 other Avions! While at it…we installed a mud flap system to protect our silver beauty!!
Back story.……When we returned from our longest road trip to date (16 days) to Dearborn, Michigan this past May/June for the TCT (Tin Can Tourist) Centennial Rally we noticed that at some point, we must have driven over some loose gravel, rock chips in a construction zone because on the curbside of our Avion front area (yes, the area where Airstreams have those protective “wings”) we had a whole lot of small, tiny dings into our aluminum skin. We know these were not there prior to our trip. It is worthwhile to note that with our multiple excursions now through Pennsylvania, Ohio, Michigan, and Indiana…that the roads in those states are not nearly as good, or well maintained as ours are in NYS. So ok, higher gas taxes, and over all taxes may have some redeeming quality…but we still live in one of THE most expensive states in the union–so not much solace there.
So we have decided to purchase a mud flag bumper guard set up for our tow vehicle which is a 2011 GMC 2500 Denali HD, 6L gas, 4 WD, Crew Cab with Leer extended bed cap (which we LOVE!!).
A mudflap system would have most likely 99% prevented these chips from happening. Only sorry we did not do sooner, 46 years on the road and our baby got dinged! Not only does a mudflap protect from errant rocks coming up and hitting your rig, or worse yet, your rockguard or windows…BUT it also handles…well….MUD (snow, slush, dead animal debris, floating garbage or UFO’s on the highway!-yes it happens!) Kevin works for NYS DOT and can tell you amazing stories of what his crew finds on the highways. Mud was the other thing that washed up onto our Avion body front during this most recent trip.
Kevin got lucky when he inquired about pricing for a Rockstar Mud Flap bumper system at our favorite local after-market auto parts detailer and installer- Mac The Knife (Mac also is the one who redid our rock guard and spare tire cover- he does great work!) Mac happened to have a left over demo model of a Rockstar brand system that he had had on display in his shop a few years back. Yeah, it was dusty but Kevin got it for less than 1/2 price off current retail …and it is the same system being sold today for over $479 list. Here is link to similar set up that we have which is currently available through ETrailer.com. FYI-We have purchased several things from ETrailer.com and are very impressed with the ease of ordering online, their quick shipping and quality products. They have a huge inventory of tons of stuff and their customer service reps are very good.
Bear in mind, these things are heavy. We realized that since this will be a one time purchase for us…and when we are in our 70’s and 80’s and still on the road (don’t laugh…we will be good LORD willin’ and the creek don’t rise!) we needed the easiest way possible to lift this baby off the back hitch to store it away if we did not want to cruise around with it on the truck (it does add weight= lesser gas efficiency when not towing)
Here is a good video to show how you hook on the system to your rear bumper.
So Kevin had the idea to create a semi-permanent fix which was to affix the flap system to the receiver piece insert which then can be pulled out with the mud flap bumper system. Otherwise, we would also have to be pulling off the entire (and super heavy) GenY Torsion Hitch with the whole mudflap bumper system attached as one unit. That GenY Torsion Hitch is also a great piece of equipment and we will do a separate post just on that and cross link it here at some point.
Steps we did:
Retro fit a longer 12″ insert reducer from 2.5″ to 2″ so that we could bolt the mud flap guard system right to that. Here is the link to the additional hardware bracket needed as well. Link to hardware sold at ETrailer.com
Kevin used a DeWalt Saws-All with brand new blades to cut off the excess length off the reducer. Be sure to clamp down the reducer so you get as straight a cut as possible. The reducer was too long and butted right up to our spare tire, so that needed to be trimmed back by several inches. Doing this however, then threw off the alignment of the pre-drilled side holes in the reducer, making use of a hitch pin lock impossible.
He then used several different drill bits to cut new holes in the correct positions needed to now be able to throw the hitch lock 5/8 ” pin through. It has a key lock and we have had it rekeyed to match the truck ignition so you always have it handy!
We followed some video’s found on YouTube for the Rockstar brand installation because as we mentioned, this was a store demo unit and therefore we had no instructions or paperwork with it.
Once installed where we knew it was properly in place, we also had to install a Heat Shield (bought on Amazon, see our link/resource page) to prevent the heat from our large exhaust pipe from damaging (a.k.a melting!) our heavy rubber mud flaps.
It is very important to have this heat shield if your exhaust goes out back before using the mudflap unit. If your pipe exhausts to the side you will not need the heat shield.
IF you are purchasing a brand new kit, you may have to put your unit together yourself. See Video As a demo model…Kevin did not have to do these steps! Ours was ready for install!
If you have any questions about this install, or why we chose our hitch or this mudflap system, feel free to email us directly at 1973Avion@gmail.com! We would love to hear from you!
2019 marked the 100th birthday of the originalTin Can Tourists club and we were excited to be part of honoring its rich history. The best part of THIS particular rally was that there were 17 Avions!
More about the history of this international club can be found here at Tin Can Tourists can be read here on their very interesting history page.
We joined TCT in 2017 when we purchased our 1973 Avion travel trailer. Its super affordable at $20 per person per year. This grants you access to their forums, newsletters, TCT swag, and of course, to attend TCT rallies that are held all over the USA! This club promotes safe, fun camping and camaraderie among fellow campers. It does focus on antique, vintage and classic camp trailers but is open to all modes of wheeled campers, motorhomes, and car/tent campers and no longer has a mandatory vehicle age to join as long as members support the goals and mission of the club. It’s no wonder that the club theme song is “The More We Get Together”. We certainly can attest to them holding up these goals. So far we have attended TCT rallies 2 times in the Finger Lakes of NY and this trip put us square one in their large Centennial rally which was held at Camp Dearborn in Milford, MI and have had terrific times. We will look forward to hopping around the country once we are full timing and attending more and more TCT events.
We arrived on Monday, May 13 at Camp Dearborn in Milford, MI. This massive city-owned park has a very unique history itself and is filled with a variety of camping options. TCT uses this camping site annually for their Fall rally which is well attended. But this spring Centennial Rally had over 170 rigs registered…for a total of over 350 attendees which was terrific. Even more terrific was the sheer variety of the rigs that converged! I took so many photos that I am going to put most of these into slideshows on this blog in an effort to save space. However some of the trailers were just SO notable that I have chosen a select few to post their photos individually as well as our photos to show what a great time we had and our campsite.
Our campsite at Camp Dearborn all set up….Site 98 (paved site, huge 8 person table, fire ring with full hook ups, 30 Amp service, special rally rate I think of $37 per night) which was right on what could be considered the 100% corner intersection which was awesome because we had such nice sweeping views of the campground and no one on one side of us since it was a corner lot. Also, the bath house is right across the lane if that is important to you.
We had been experiencing some very chilly and rainy weather along the trip, but as soon as we got to Camp Dearborn it seemed the Sun God decided it was time to give us a break and it reached into the mid to high 70’s nearly every one of the 5 days we were at the rally. Perfect camping weather!
The Centennial rally boasted a nice selection of group activities each day. Not too many to where you feel you are on a hamster wheel but each evening there was a different nationality themed dinner. (actually we would have liked to see a few more “how to” or other types of learning/sharing workshops during the day as options to attend). Italian, French, Canadian, Polish Buffet dinners all were good. It was actually fun standing in line with 100’s of fellow “Canners” and those lines moved fast but allowed all of us to get to know each other. The “big tent” was also the site of live band music 2 different nights, a few slide shows, safety workshops, new member welcome and the Centennial Rally Dance which touted a “Roaring 20’s” theme that we dove into (well, I dove….Kevin came along for the ride as a wonderful husband will do!)
Here is a slide show of some of the unique campers that I took photos of. These certainly are just a sampling of what was there. Kevin and I enjoyed taking full walks around the entire massive campground on their paved roads at least 1 x per day to see what had just pulled in since some folks started coming in on Monday like we did, but others continued to come in all the way up to Friday afternoon. So each walk held new surprises to see!
One of the special features of this particular Centennial Rally was that any vintage rigs “Made in Michigan” were specifically featured and showcased. TCT did that by issuing each of us a special commemorative sign that we had out and could keep. Also one evening a guest speaker did a great presentation on Michigan “wheeled” industry from car making in Detroit to RV trailer making history.
Even our dog Reddy got into the act by wearing her “Avion” sweater I had recently crocheted for her. She also loved her stroller since at age 11 her arthritis gets the best of her on long walks we did around the rally. Many thanks to Avioner Rhonda who has now given me a Travelcade patch to sew on Reddy’s coat to complete the look!
With this “Made in MI” focus, 17 Avion trailer owners descended on this rally and it was so completely awesome to see Avions of all ages, sizes, and levels of renovation!! We met several new Avioners who we had only known of by mutual facebook posts (so nice to put faces with names!) , but also got to get even better reacquainted with several Avion owners who we had met 2 years ago when we attended the Silver Avion Fellowship Rally in Elkhart, IN. (which we are attending again this summer!) Truly building these relationships with fellow Avion and other vintage camper lovers is such an important part of our zest for this hobby. We learn, laugh, share and support each other.
HERE IS THE AVION TRAILER SHOWCASE!!
We stayed at the rally until Sunday morning and then pulled out to take a fairly easy time home. We (well, Kevin did) drove 7 hours through MI, OH, PA and into NY along Interstate 90.
As part of our trip home we overnighted at a winery who is a member of Harvest Host which is a membership organization that allows wineries, museums, golf courses, historic sites, organic and regular farms an opportunity to showcase their facilities by allowing Harvest Host RV members to stay overnight on their property. These are typically boondocking overnights and only fully contained RV’s (motorhomes and trailers) are allowed. No tent camping is permitted. Some hosts we have seen do have some limited hook ups, some will allow a few nights if requested. The impetus of this is that the RVer will support the business by taking a tour, a tasting in their winery, purchasing of goods at their site store in lieu of being charged for a camping stay.
We stayed at Merritt Estate Winery, a Harvest Host member which is a nice place, but admittedly, their parking lot and accessibility could be really challenging if you are not coming in at a very “off” time, e.g. early in morning or definitely before 2-3 pm. After that time of day, if there are any trucks, vans or cars in their parking lot- where they want you to turn around in is going to be really tough unless you are a small camper van or small class A. When we got there, they had not moved a large white truck or van of theirs out of the parking area where they wanted us to turn around in . They say they are tour bus friendly but I suspect that the buses disembark their passengers at the top of the driveway, not below in their small parking lot.
We did enjoy having a nice quiet picturesque site and the wines were good and gift shop had some nice cheeses and I bought three bottles of their wine…so we more than paid for our site in the end. But a Harvest Host site is a nice alternative, and this site was only about 10 minutes off I-90 which made it also convenient. Below is a slideshow of some more pictures of our overnight at Merritt Estate Winery.
A word of warning to fellow Harvest Host members, PLEASE check out their Harvest Host site using Google Satellite before committing to go. Call the host on the phone and clearly discuss what kind of space and turn around area and access they have. These owners (normally non RVers) do not understand the turning and backing capabilities of RVs. Our combined rig and trailer is just under 50 feet long and cannot spin on a dime. One Harvest Host site in OH we had checked out enroute to MI would have been a disaster trying to use, although the owners were very willing to have us stay over.
If you are interested in joining Harvest Host, please use our exclusive 15% discount code! You save money and we get a small referral fee credit (that we put towards future purchases at Harvest Host site gift shops to support their businesses)
Hope you have enjoyed our Part 2 of our Spring 2019 trip in our 1973 Avion. Here is a link to Part 1 (Watkins Glen/Finger Lakes to Frankenmuth MI) if you want to check that out! If you want to be sure to get notifications of future posts and travels, please subscribe to our blog!
We are among tens of thousands of RV owners who due to many circumstances (work being ours) we cannot just pick up stakes and move to follow the “70’s” (temperatures that is!). That day WILL COME….but just not now!
So we, like many will do the annual ritual of putting our RV “to bed” in winter storage.
I thought I would share with our followers some tips and pointers that we have employed and picked up along the way from other veteran RVers.
New to our routine this year is the employment of low voltage LED tube rope lights on the floor underneath the perimeter of our 1973 Avion 28′ travel trailer.
In following one of our all time favorite fulltimers, AStreaminLife.com, Steve and Courtney have promoted the use of under trailer lighting to ward off mice and other varmints when camping in the great outdoors. Using their suggestion, we have purchased solar powered spot lights (check out AStreaminLife’s Amazon shop for the ones we purchased based on their excellent reviews) to use when boondocking and then the above pictured LED Rope lights when we have electric hook ups available.
Well, so we got to thinking that if this has worked for them in the wild….why would it not also serve as a good deterrent indoors? Since our RV storage garage (we rent near our house) has electricity (and we pay a little more for that each month) why not use this low voltage LED rope lighting we purchased to use while camping….during the winter too! I akin the look to a bit of a “STAR WARS” effect!
We have consistently put rat/mouse bait traps in and around this garage for the past two seasons where we have stored our Pewter Palace. This has been more of a preventative action but we have seen where the little green bait blocks have shown some “tooth wear” from nibbling varmints so yes, they are there. BUT we have, knock on wood, not had ONE bit of any hint of varmint intrusion into our RV itself.
A few things you will need from the store before you dive into winter storage prep:
BOUNCE Brand scented dryer sheets (get the big box!)
Clorox (or similar with color-safe bleach) brand pop up wipes
Scented draw string tall kitchen garbage bags
LED Rope lights, white light bulbs- not colored
RV Antifreeze (the pink stuff!)
Plastic box type varmint bait boxes and the green hard bait blocks (these do not trap the varmint and let them rot in there, they bait them to the green block which then eventually kills them when they go to see a water source away from your rig!)
NOTE: for the purpose of this blog post, I am not going to go through the entire black and grey tank dumping and prepping procedure or the system flushing for long term storage. I am purely focusing on interior tips for winter storage to protect from varmints and any damage to interiors.
A few basic and kinda “no brainer” tips to prepping your RV for winter storage:
Remove ALL and ANY types of food stuffs, oils, herbs/spices -ANYTHING that acute little noses could sniff out and consider a potential food source during bleak, long winters.
Remove all liquid, aerosols, pumps and semi liquid items including canned goods because freezing will cause them to burst and create a total mess (not to mention serve as a glorious buffet dinner for varmints)!
Remove any rags, towels, pot holders that may contain even trace of oils, food handling, etc. Varmints love to nest in cloth and paper goods like paper towels, napkins so remove them too and use them at home over the winter or store for next summer…..if you leave anything hang it on a hook or put in a scented trash bag with a Bounce brand scented dryer sheet in side bag with items.
Wipe off all counters, refrigerator inside and out, stove top, table tops, sink, dish drainer, cutting boards, pots/pans with a Clorox bleach brand pop up style wipes.
More about the cook stove– be sure to lift the stove top off, remove any crumbs, food particles, grease where the mechanicals are and wipe down entire area, grates, gas pipes, burners, etc with Clorox wipes,
Use a Clorox (or similar) brand pop up wipe to go over interior and exterior of refrigerator, toilet, sink, tub, all handles in kitchen and bathroom areas in particular.
Why Bounce Brand? We have sworn by the Bounce Brand of scented dryer sheets for over two decades now when camping doing our living history reenacting to keep away varmints AND crawling/flying bugs and insects. Doing this type of camping we use a canvas tent, a canvas floor cloth (that is not connected to the tent sides like moderns are) and have often slept on air mattresses on the floor. We are sometimes camping for 3-8 days and in all sorts of open fields, woodlands and in all sorts of weather conditions. Bounce sheets are excellent for putting around the perimeter of the interior of a tent and they really DO keep insects away. A benefit is that the inside of the tent always smells nice too! We put sheets under our bedding, around the interior perimeter of the tent itself and inside our clothing bags/boxes. It serves to rights that Bounce’s ability to ward off insects and varmints in a tent will do the same in a garage and RV! We have used them successfully when we owned a Class A motor home for five years and now in our Avion for past two years. (knock off brands have not proven themselves nearly as effective!)
Prepping your bedding and cushioned areas:
We strongly recommend tilting up all mattresses and cushions that are in your sleeping and dining areas if you cannot or chose not to remove these completely and store them at home over winter. Not only does this provide less of a “hacienda of dark seclusion” for any varmint intruders to build a nest, but it also provides far more air circulation around such materials thereby inhibiting mold, mildew, etc from building up on both the cushion/mattress and the boards that lay underneath them.
Doing this we have (knock on wood here…) never had any issues.
Below you will see on the left photo, our dinette cushions standing on long end and one of our twin mattresses on its side. Note the other bagged items and placement of dryer sheets all around too! These bags do contain comforters, extra throw pillows, beach towels. We DO take our bed sleeping pillows home for winter storage and do not leave them on the RV.
What about Clothing Storage over the Winter in the RV?
We do keep a complete set of camping clothing on our RV at all times so we are ready to go at a moments notice. We keep things organized by putting items in plastic lock lid style shoe storage boxes (they fit best in our over bed cupboards) and under bed lock lidded plastic totes, so winter prep is actual pretty minimal.
Here are some additional steps we do take for winter storage for clothing/dressing areas:
Bounce sheets get put inside the floor of all drawers and then on top of any items left in drawers. Bounce Sheets also get placed inside every overhead storage cupboard and placed in every scented trash bag that is used for linen storage.
I am sure to remove any liquids, eg. perfume, deodorants, mousse, hair spray cans/pumps, etc. due to potential for freezing/bursting. Check bathroom areas and remove from all over and under cupboards from bath area too!
We remove any leather shoes/sandals due to potential for dusty mold and leather could be a food source in a pinch for varmints. I leave things like rubber flip flops, crocs, etc.
Final Steps… that are often forgotten!
Remove ALL batteries from any flashlights, headlamps, portable radios, clocks, alarm clocks, kitchen devices, etc. and TAKE THEM HOME and use them over the winter.
Ensure you have correctly used RV antifreeze in your systems and retain some visible in the toilet bowl and put an extra dose down each sink drain to ensure there is some sitting in traps and bends in piping.
Be sure you have put Bounce sheets also in all interior AND exterior storage/mechanical areas like water heater box, oven fan area, exterior refrig access panel area, sewer service area, exterior storage areas that go underneath dinettes or beds, etc. Here you can see our furnace and sewer pipe vent area being protected with dryer sheets.
Some notes on exterior/interior prep…
If storing your RV outside in winter the issue of “to cover or not to cover” is going to be yours. It is recommended that all aluminum campers like our Avion and Airstreams NOT be covered because covers can adversely scratch the surface. That being said, we do know Avion owners who have had decent luck with covers-much will depend on where you live. If you do use a cover, be sure you allow sufficient ventilation so that mold and mildew do not happen inside the RV.
If your RV is outside in winter, be sure to check pressures, treat the tires with tire protectant and cover them from daylight with either a tire cover and/or sheet of plywood, etc.
Close all curtains to prevent fading of cushions and interior finishes-especially if wood interior like ours is. If you have those pseudo fabric type pleated horizontal blinds I believe it is NOT recommended to drop them down as the pleats will stretch out and the shade will not look or work well in future. Perhaps in this case, if no curtains are available to draw closed, then take some old sheet, cut it up and place it over the valance and hang down over window to prevent interior fading while keeping the fabric blind up and pleated for storage.
We do not recommend installing Reflectix or similar silver insulation batting on windows because you may cause undo condensation on interior of windows unless you keep ceiling vents open to allow air exchange. Plus, using Reflectix inside on windows will create a totally dark cave inside your RV which is what varmints would just love!
Spray all locks (storage bays, doors, hitch locks, spare tire locks, bike locks, etc) with your preference of lubricant to keep in good shape when not used for length of time.
Put RV house batteries on trickle charger.
Chock your wheels, sounds crazy if you are on a level garage, but its just one of those things Kevin is fixated about…but its good practice because once you get in the behavior of always chocking your wheels you are less apt to forget when really needed!
You have NO IDEA who may be able to access your storage area……why take a chance?
Lock your RV doors even if in a locked storage garage.
Apply your hitch lock even if RV is locked in storage garage.
As possible visit your baby at least once a month over the long winter— just to do a quick visual check around the inside and outside and to hug her and let her know you miss her and cannot wait to get back taking her camping again!
Safe Travels! We LOVE to hear your feedback about this post or any of our blog posts!
Over the last 9-10 years, Kevin and I have put considerable time into researching, planning and beginning to execute a thoughtful plan towards our goal of “going full time” RVing. In this blog post we tell you about four of our most favorite RV bloggers/vloggers and include a little about them and links to their blogs and YouTube channels. They are entertaining, inspirational, educational and oh yeah…..travel to amazing destinations!
Originally and shortly after we sold our Class A 32′ motor home back in 2012 we realized then–after she was not in our driveway, how much we missed life on the road. Albeit at that time, and it continues, we only get to do long weekends and the occasional big trip of a week or two around the eastern half of the USA but—each time we do we are more and more convinced this is the right path for us. We also know it is not for everyone.
Along our journey we have found some truly inspirational friends in bloggers/vloggers who have chronicled their similar journeys from the decision to forego the traditional and head into the non-conventional life of making a rolling home….your only home. We also have learned there are many variances in between this. Some people live a portion of their year on their RV while returning to their sticks N bricks for the rest of the time. More times than not, these are snowbirds who fly south in the winter RV in tow (or behind the wheel) and spend a warm and sunny February in FL, AZ or TX.
There are others who “escape” the brutal hot sizzling summers of those same places for their “camp in the northern woods, cottage on a New Hampshire lake or the beach family compound on Cape Cod or the rugged shores of Maine. For many and varied reasons they prefer (or cannot quite imagine not having) a structure to call home base.
For us….that decision was easily made. We did not want to be tied to the maintenance of our rolling home AND the maintenance, cost and distance filled with concerns about the safety, etc. of a northern sticks N bricks home base. We would rather have what we own on our back so to speak and know that where ever we wanted to be…we would be and that could change from year to year, season to season depending on where the wind and whims blew us. I personally have owned one home or another since 1982 and I am more than ready to not have that responsibility. We simply do not want to deal with frozen pipes, switching out storm windows or raking leaves in our retirement years. Been there….done that….done!
So we watched, learned, read, and chatted with many who have made similar decisions such as ours to “go full time”. This is not a decision we have made on a whim. But don’t be fooled, we have some family and friends who think we are nuts….and others-like my adult children….who are totally supportive and know we will succeed.
After being “RV-less” for about three years the itch became unbearable. We started falling for Airstreams but did not want to do a total restore and ones in road worthy, camping shape were out of our price range. Quite by accident we stumbled upon Avions. Their iconic aluminum, rounded exteriors, quality interior and exterior build and their reputation for excellent tow-ability had us sold. It took us another two years to find one we wanted….and although we had anticipated having to fly across the country to buy one, we found one on Craig’s List right in VT not more than 15 minutes from my daughter and son-in-law’s house!
We purchased our 1973 Avion, 28′ LaGrande in September, 2016 (some Birthday gift for me eh??!!) and we have never have looked back. Each month we grow more and more fond of her. We sold our house in Oct. 2017 and moved into a townhouse apartment all under the methodical plan of incrementally doing our downsizing exercises in prep for full time RV life when we retire.
Below are a few of our very favorite bloggers/vloggers and for various reasons we have noted underneath each one. Along the way we have internalized and put into practice some of their suggestions and methods, and in other cases it forced us to have heart to hearts with each other to realize….yeah, that may have worked for them…but we will be more comfortable doing it “our way”. Watching literally hundreds of hours of YouTube videos (we subscribe to most of our fav’s so we don’t miss an episode) to reading countless articles and books on the topic….we have grown in our understanding of what life is like on the road…and what we as a couple expect from the journey, each other and life in general. It has been a good way to learn…together to prepare for this next chapter.
Here are our favorite bloggers/vloggers. They are not in any particular order because each offers us different windows on life on the road that are equally important in our planning phases. You will notice a bit of a pattern here where 3 of our 4 fav’s are also Airstream owners. Similar enough to our Avion…we all love round aluminum corners! LOL
A Streamin’ Life: Steve and Courtney. Now mid- 30-somethings who figured out a way to retire early (31 & 34) and we have followed since their decision to sell their two houses a couple years ago (had recently married), sell their stuff, purchase an Airstream (an older one, 30′) and hit the road full time. Both were still working the first year in their Airstream, living stationery in an RV park in Tucson, AZ while preparing their rig (and themselves) for hitting the road full time. They are level headed, practical and very good money savers and managers. Their blog is full of helpful videos on managing trip expenses, planning big trips and week long trips, downsizing to what is really needed and what is not. They travel with their two dogs which also has given us tips on travel with our dog, Reddy as well. Courtney and Steve are a terrific resource for how to determine your financial needs to go full time, save up for early retirement and more. The recently launched a terrific online course to teach others how to plan Epic RV Adventures– for more about that click here. To check out more about Courtney & Steve and their adventures around the USA visit…..Their Blog/websiteTheir YouTube Channel
Less Junk, More Journey: Marisa and Nathan. Once again, these are “kids” as we refer to them as…basically Marisa is one year younger than my son, and Nathan is three years older than my daughter. I am sure in some way I live vicariously through them and their journeys trying to imagine them as extended family. Kevin and I will often refer to them as “the kids”. Their blog has some terrific, easy to navigate pages like their FAQ that really gives you a terrific way to see their answers to many questions you may have about how they made their decision to go full time, steps they took, etc. Their young daughter, Hensley is a year younger than our grandson Lucas and a year older than our grandson Sawyer. She has been on the road since infancy and it is so fun to watch her explore, learn and travel with her fabulous, down to earth parents. Watching where they go, how Hensley enjoys it and some of their methods for keeping sanity on the road with a toddler has given us great ideas for when our grandsons are with us in our RV (it is our hope and plan that they will do more and more of it as we have more time to travel) Their Blog Their YouTube Channel.
Long, Long Honeymoon: Kristy & Sean. Also known as “Lo Lo Ho“. What started out as a honeymoon on an RV has progressed into well over a decade of extended travels from this wonderful couple. For over 12 years, Kristy and Sean have made dozens of highly informational videos on everything from backing into a campsite, to dissertations on generators,hitch locks, and many more pieces of equipment, etc. to their epic journey across Alaska (actually our other two bloggers have just done the Alaska trip now too in the last year!) Last year, Sean was diagnosed with a cancerous brain tumor but with proper medical intervention and a bit of a slowing down of some of their multiple month trips he is fully on the mend with no tumor reported at his recent medical check up. Wow! miracles do happen! This couple maintains a bricks N sticks home and plans big trips each year to various parts of the USA from the Keys to Maine, from Seattle to Atlanta and everywhere in between. Their video titles are well organized and were especially helpful when we first started RVing….they have some great tutorials to keep you out of trouble! Their sense of humor and little bit of Laurel & Hardy type of format is so fun. Sean’s writing style and sense of humor is unbeatable and Kristy is the perfect foil! Their BlogTheir YouTube Channel
TechnoMadia: Cherie and Chris. These were one of the very first full time RV couples we found and began following. They are wanderlust spirits who travel the country in their upgraded retro vintage bus (yes, converted from a passenger tour bus). Their specialty is their amazing knowledge of tech tools, internet on the road gear, trouble shooting electronics and over the years they have tested, reviewed and scoped out many pieces of internet and mobile gear that full timers may need or want. A little over a year ago, Cherie and Chris decided to park their RV bus part of the year and bought a large trawler style yacht which they plan to do the “great loop” the Inter coastal Waterway around the eastern/central USA in sections over the next five years or so. They are typically based in the FL area but also do presentations and speaking engagements at many large national rallies so they also travel all over. They could be considered more of the senior statesman when it comes to full time life on the road, having done so for well over 15 years now. They travel with Kiki their cat who is a star all on her own. Their Blog Their YouTube Channel
Summing it all up…..
We appreciate the time and talent that each of these bloggers/vloggers bring to the world of full time RV living or mega traveling. Each of them share a candid snapshot all the time into their lives, their ups and downs, their triumphs and tribulations. We have learned so much and not to seem like we are bragging but we sense we are far more informed that many other would be, soon to be, or already are..full time wanderers. We owe this all to these folks and the many others who we watch from time to time on their blogs. We follow or at least check in with about a dozen RV couples and singles who focus on various subjects. We simply wanted to highlight the top four that we follow…otherwise this blog post would be longer than it already is!! LOL
Thanks for tuning in. Please visit our friends above. and PLEASE……Let them know that Kevin and Luisa Sherman from “The Pewter Palace.com” turned you on to them!
Safe travels and please subscribe to our blog so you don’t miss a another post!
Clearly anyone who owns an Avion understands that they are historic preservationists in the most fundamental sense. Not only do they maintain, restore and covet their aluminum beauty…they also USE it as it was intended to be used—for enjoying the outdoors, sheltering from weather and creating memories with loved ones and dear friends. If they did not revere history and love nostalgia they would own a modern cardboard box, flat top trailer with little to no personality and certainly not built for the longevity that the Avions can boast to this day. (our Avion turned 45 years old this year-2018, and I challenge any modern box campers to be on the road in excellent running order in 45 years!).
NOTE: at the end of this blog post I have a list of resources for reproduction items talked about throughout this post. Enjoy!
Almost monthly, there are questions about, or seekers of information on the various medallions, decals, numbers and company markers on the trailers.
In this article I will attempt to answer many of the questions and in some cases provide some current links to where some of these items (or reproductions of same) may still be obtained today. Also included are links to other websites where directories of the Travelcade member ID # may still be looked up. Sadly, currently no one source of all those numbers exist so the hunt is on and if someone would eventually scan and post the books in an archive it would be like winning the lottery for a lot of us! More about that in a subsection below.
Lets start at the beginning…the birth so to speak when an Avion was coming off of the assembly line.
As a side note, see our post about our trip to Benton Harbor MI in April 2018 to see a video of the plant that still exists but now is a cheese factory.
Avion Coach Company Medallions and Logo Markers:
These logo medallions from what we have seen were almost always painted red. Today many look like a pale/faded tomato red, but from what we understand a deep true red was more similar to its original color. Over time, the colors have faded. This is the same with the rub rail- that vinyl strip that slides into a channel that goes around the trailers mid-belly in two layers with a shiner (non-anodized) strip in between them (at least on the years surrounding our years of production. In the 80-90’s the colors for Avions turned more to using blues and black. You can see that along the way one of the three previous owners of our trailer replaced the rub rail with black which is very common to see these days. The rub rail material is not easily found in the right size. Resource list at end of this post. Some people have taken to painting the rub rail vinyl back to red, or from faded black to black. It can be done, but I have seen them and to me it looks a bit like a cob job. Perhaps if you were to actually remove the vinyl and spray paint it it might be better—but no way am i promising you will ever get that rub rail back in the channels again very easily!
As another side note to the company medallions, above is the dealership plate from where our 1973 Avion was originally sold from. This dealership does not exist anymore but we have located where it was through old news clippings and at the time surely it was on the outskirts of Dearborn Heights in a rural area– but now that address is smack dab in the middle of a very built up almost urban environment. Our little lady did not travel that far from her birth place to be purchased for the first time. Many Avion’s also still have their original dealer emblem on them. Again, its all about nostalgia for us and we wear it proudly.
Below is our LaGrande “model” medallion which appears on both sides of the trailer to the rear-basically even with where the bathroom is located (at least with 70’s models). Early Avion photos (50’s-60’s) we have seen do not appear to have these though there were some model names. See second photo below for placement. Many of these model plates that we have seen are, like ours is pitted. They are stainless but age, and in our case, being kept in Florida near the ocean in the winters for many years has caused the pitting. If a rig has been kept under cover or in a garage these emblems may be in far nicer condition. The background is dappled/textured a bit and supposed to be painted all flat black. Only the raised lettering is supposed to be shiny. The “Travelcade” models (a wee bit of a step down, basic model of Avion) also have them in the same locations. It is not advisable to remove these unless you really know what you are doing. (again, this was before our baby had her first bath!)
HOW CAN I TELL HOW OLD MY AVION IS AND HOW LONG IT IS? In the photo below you will see the vehicle details on the orange plate that was afixed to the trailer upon completion at the Avion assembly line plant. This is not our trailer but you can see and tell the year, month, and production # as well as the model style “LaGrande”.
These plates are very important when looking at purchasing a new to you Avion or for reference for a rig you currently own. Hopefully you still have one on your trailer. This one is located just to the right of the door entry. This is also where ours is, however there is another plate on the streetside as well that also has important trailer information and should be documented.
There is an excellent resource website maintained by “DR G”, Dr. Don Gradeless that is a treasure trove of manuals (PDF by year) you can download or view, info regarding Avion specs and also early rosters of some Travelcade member units.
Here is how to read the numbers (see image below)- this stands for trailers made at least in the 1970’s that we know and cannot attest to how earlier or later models may be marked.
SERIAL NUMBER 75-L-28043
1975 production year L = LaGrande Model 28 = foot length043 = 43rd trailer made that year.
Trailer Travelcade Member ID Numbers and Units:
I will be including a whole separate blog post about the history of the “Travelcade” membership club because it really was cool! But for purpose of this post, I refer to the wonderful Avion history book written by Robert Muncy (link to purchase here) entitled SILVER AVIONS AND CAYOS. Muncy writes that the Travelcade club of Avion owners got its start in 1959 and had its highest rendezvous turn out of 818 Avions in Coldwater MI in 1970. Please see my future post about the Travelcaders and their club soon!
The photo below is our Avion, our “Pewter Palace” as we call her with her original Travelcade ID numbers and geographical unit emblem. Not all Avion owners joined this optional club and so if you do not see any type of stickers like this (front and rear streetside is where they should be) then the owners did not partake. Benefits of the club included a printed newsletter, attendance at rendezvous (FL, MI, WI) and the ability to order and wear some of the truly awesome “Travelcader Swag” like earings, jackets, knitted caps, pith helmets, bolo ties and more….remember….this IS the 1960-70’s!! See some of the swag we have gotten so far in this previous post or on our Avion Swag post page.
Our trailer’s second owner was from CT and therefore was part of the New England Unit which sadly no longer exists. In fact, the whole “Travelcade” club and movement died out after the corporation sold to the Fleetwood RV company in the 80’s. Happily, a diehard group have resurged the zeal for hosting rallies of Avions again and now there is are very active “Sliver Avion Fellowship ” units based in MI, TX and more recently one started in Arkansas. The trend and desire to all get together again is growing each year as is the popularity of owning one of these classic, well-built beauties. We attended the Silver Avion Fellowship Rally in Elkhart MI in the summer of 2017 and had a blast with over 25 Avions of all designs, lengths and styles present. The MI group, I believe is the one who got the whole Fellowship rolling again. Search Facebook for The Silver Avion Fellowship and ask to join. There is a similar named fb site for the event too. I believe that black numbers and letters were the standard issue of these rigs. People attending the Travelcade official rallies back in the day would register with their trailer number. There were published member directories for each year and geographical unit. If you are lucky, someone at one of today’s Fellowship Rallies may come with one and you can look up your original Travelcade member’s name, address, etc. On occasion someone will also post out on one of the Avion FB pages that they have access to one of the books , or you can post out on the Avion Owners facebook pages that you are seeking a “look up” for the numbers on your rig. Folks are more than happy to help find this nostalgic piece of history out for a fellow Avion owner.
As you can see by our membership number—our trailer owner’s were the 14229 members enrolled. WOW!
Below these emblems, or on the curbside somewhere near the front side panel, some Avions also have a vertical list with smaller letters of the location and date of EACH Travelcade Rendezvous that they had attended. It is an amazing story for your Avion and we highly recommend that you LEAVE it, or if needed get repro stickers if some of the letters or dates are worn off. Some trailers only have a shadow (left from fading of the finish) on their rigs. Again—this is a badge of honor that should be maintained in our opinion and we know many other Avioners agree. So please keep them visible! We wish we had some but perhaps our owners were more interested in just reading the member newsletter than traveling south. We do know they took our trailer to Alaska twice though!
If you look very closely below you will see under the “pie slices” a discolored area on the body. In the right light, you can see EACH of the rendezvous that this trailer has been to. It was quite amazing and yes—a badge of honor we are happy to see they have kept even though the actual black letters are long gone. Those letters were issued to you when you arrived at the Travelcade Rendezvous. Today’s Silver Avion Fellowship Rally we attended in MI is reissuing these once again and we will put it on our trailer once we get our clear coating done by Chuck Cayo this spring.
Below are some resources for items mentioned above. Please do remember to check back to my blog often as I will be adding an entire post about the Travelcaders and club which will include some vintage photos of rallies, people wearing Travelcade swag and more… including where to buy reproduction Travelcade Large Member Stickers like what is on the front and rear of our rig (we have purchased new ones to replace our very faded and worn out ones)
CURRENT RESOURCES THAT WE ARE AWARE OF:
(these were viable at date of this post, sorry if no longer active) Please contact me if you find new or other sources!!
(1) Chuck Cayo (above) keeps black in stock most of the time.
(2) Others have used sources found on Airstream (gasp!) forums, recently someone used vinyl stripping found on a website that sells it for lawn chairs. He said it worked well. I got some samples, nice colors but is very thick and not sure how well it will last with temp changes/extremes of full timing plus would be really hard to insert in because it is flat, not curved and very stiff. They said do it on a sunny warm day, and use a heat gun to soften and insert- perhaps with a putty knife to help tuck into track gutter.
(4) Travelcade Member ID #’s and Units: This is a very recent link that I found posted on one of the handful of Avion facebook pages that i belong to. So far, I believe the folks who have ordered from her have had a positive experience. Mind you, you must have a steady hand to apply these…or take the letters and numbers to a professional sign shop or automotive detailer who does this kind of thing and have them apply them! As mentioned, so far, we have only seen black letters on originals but I believe some current owners are using red for their numbers. I guess its a matter of choice.
As always, I hope you have enjoyed this post and gotten some “take aways” from it. I would love to hear your feedback, or if you have other sources for the items discussed above or anything to do with Avions. Its all about helping each other to preserve and enjoy our beloved Avions as much as we call.
We look forward to meeting fellow Avioners on the road in days ahead….till then…
ONE LIVE–LIVE IT!
Adventures with a Vintage Avion Luxury Coach Camper